Updated 3/28/04
Rambler Dan’s 1968 Rambler American Parts List
Note: I DO NOT SELL PARTS! These numbers are provided for the benefit of owners.
If you can’t find the parts you need at a local retailer, see the
Planet Houston AMC Vendor List.
The AMC Rambler Club
also publishes an extensive list of vendors.
This list is based on parts I’ve purchased and used successfully, info from catalogs and contributions from other owners.
I am no stickler for authenticity, and will happily substitute a part made for another car if it works. Parts I know are not OEM spec are
marked with a dagger (). Finally, I make no guarantee as to accuracy.
Any additions or corrections are welcome.
Also see the lists at Dan Meyer’s
and Matt Brodeur’s sites.
Key to manufacturers
|
| B-W | | Borg Warner |
| Ray | | Raybestos |
| Fed | | Federal Mogul (formerly TRW) |
| S-P | | Sealed Power |
| BCA | | Bower |
| CR | | Chicago Rawhide |
| Pur | | Purolator |
| Motormite | | aka Help! |
| Mopar | | Put "J" before AMC number,
omit punctuation. |
|
[Brakes] [Steering/Suspension]
[Driveline] [Electrical/Misc.]
ENGINE—199 cid I-6 w/Holley 1-bbl
Air filter Fram CA184 Pur A30045 Lee AF184
Motorcraft FA-1R Wix 42054 ACC 71104
Free-flow filter (will not fit OE housing) Fram CA189 Pur A30059
PCV Pur PV765
Oil filter AC PF31, PF24 Lee LF7 Motorcraft FL2, FL2DP
Fram PH11, PH25 Pur L30005
NAPA 1049, 1055 Wix 7, 17, 51049, 51055
Oil filler cap Stant 11066
Fuel filter (in-line) Fram F2111
V belt NAPA 2509153 Dayco 15365
Thermostat NAPA THM183 Stant S300-190, 45359 Gates 33009
T'stat gasket NAPA 1060ST Victor C24003
Felpro 35024 Engine Seal 35024, 10-1166
Coolant temp sender Sorensen TSU41
Hose, upper Dayco 70561
Hose, lower Dayco 70481
Water pump PAW* 150065 Arrow* 71247
Water pump gasket Felpro 13877
Points NAPA CS788, CS788P B-W A209 Standard DR2240X
Condenser NAPA RR176 B-W G126P
Rotor NAPA RR182R B-W D152P
Cap NAPA RR183 B-W C168
Plugs Bosch 4220 (was WR8DP)
Wires NAPA 700101 B-W CH616, 73694
Ignition coil Accel 8140 B-W E30P Sorensen GC122S
Distributor NAPA RAY 48-1646 Remain* ADI2217
Alternator Xcel* 7099 Prostart* 7091
(40 amp Motorola) (55 amp Motorola)
Regulator (1968) NAPA/Standard VR112 B-W R290
(post-68; new plug) NAPA/Echlin VR1010
(Post-70 Hornet) B-W R292
Carb (Holley #1931) NAPA CHE 951 Pep 64-3099 Tompco (?) 1-117
Carb rebuild kit NAPA CRB 2-3537 (was 2-5317) Sorensen 96-138A
thecarburetorshop.com 1852 Hygrade 368A
NOT: Hygrade 533B (for Holley #1920)
Carb gasket Felpro 60044 NGA G26639
(Fits AMC and IHC (Future No: 13-1028)
six, 1965-73; Chevy and
Pontiac four, 1961-77)
Choke coil NAPA 2-236
Dashpot NAPA/Echlin 2-4531
Fuel pump NAPA RAY 240786 Pep 40755 Master 40755
Inline fuel filter Pur F21111
(replaces GF11-11)
Starter solenoid Pep 631114
Cam kit Melling CLSRC 6
Lifters TRW VL58 (HT2011)
Push rods Melling MPR331 S-P RP3199
Valve seals Felpro SS70530
Timing chain TRW TC494 S-P 222-494
Timing gear, upper TRW S354N (nylon)
TRW S388T (steel)
Timing gear, lower TRW S355
Timing cover gasket NAPA JV878 Felpro TCS45117 Standard TCSS802
Oil pan gasket Standard 2802 Felpro OS13881C1
Oil pump S-P 224-41199
Oil pickup tube S-P 224-11199
(NOTE: Replace pump and tube together; old and new designs are incompatible.)
Head set NAPA HS1199VC Felpro HS8169PT2
Head gasket Felpro 8169PT
Valve cover gasket NAPA VS39695 Felpro VS50258c (extra thick)
Valves S-P V1981K
Motor mount NAPA BK602-1162 S-P V2023K
[Top]
BRAKES
Master cylinder (drum) Ray MC36237 (new)
Ray RMC36237 (rebuilt)
Repair kit Ray MK1630
Master cylinder (disk) Ray MC36386
Wheel cylinders, 6 cyl.
LF Ray WC37014 EIS EW 46251 ? SH25601C
RF Ray WC37015 EIS EW 46252 Wagner FD36825
Repair kit (both) Ray WK164
Rear, 15/16" bore (both) Ray WC37016 EIS EW44453 Guardian/Wagner/
Master 50014
Repair kit (both) Ray WK170
Wheel cylinders, 8 cyl.
LF Ray WC37125
RF Ray WC37126
Repair kit (both) Ray WK471
LR, 7/8" bore Ray WC17507 EIS EW9021
RR, 7/8" bore Ray WC17508 EIS EW9022 Bendix 33290
Repair kit (both) Ray WK129
Flexible brake hose
Front (both) Ray BH36612 NAPA UBP36612
Rear (both) Ray BH36801 EIS SP3764 Guardian F86594
Emergency brake cables
Front Ray BC92257
LR Ray BC92258 AMC 317-2991
RR Ray BC92259 AMC 317-2992
Front brakes 9 x 2 1/2 (6 cyl.)
Shoes Ray FR432 Bendix 432, R432, AF432, RAF432
Drum Ray 2502 NAPA 640-1074 Bendix 140105
Studs Ray 1113B NAPA 641-1114 Bendix 142074
Nuts Ray 1200N Bendix 142025
Spring kit (hook spring
type, front & rear) Ray H7037 NAPA 2215 Bendix H7037
Spring kit (nail type,
front only) USA 7043 Gibson 7043 Bendix 7043
Hold-down kit (nail type,
front & rear) Gibson 40429-2 Bendix 40429-2
Self-adjusting kit (L) Ray H2516
Self-adjusting kit (R) Ray H2517
Adjusting wheel ass'y (L) USA 1522
Adjusting wheel ass'y (R) USA 1523
Front brakes 10 x 2 1/2 (8 cyl.)
Shoes Ray 155
Drum Ray 2506 NAPA 640-1142
Studs Ray 2200B
Nuts Ray 1200N
Spring kit Ray H7064
Self-adjusting kit (L) Ray H2514
Self-adjusting kit (R) Ray H2515
Rear brakes 9 x 2 (6 cyl.)
Shoes Ray FR433 NAPA B1114 Bendix 433, R433, AF433, RAF433
Drum Ray 2501 NAPA BK6401075
Studs Ray 528B
Nuts Ray 1200N
Spring kit (hook spring
type, front & rear) Ray H7037 NAPA 2215 Bendix H7037
Hold-down kit (nail type,
front & rear) Gibson 40429-2 Bendix 40429-2
Self-adjusting kit (L) Ray H2516 NAPA 80665
Self-adjusting kit (R) Ray H2517 NAPA 80666
Hold-down spring Wagner F34898
Hold-down spring anchor Wagner F34820
Cable clip Wagner F110379
Hose lock Wagner F3052
Dust cover Wagner F17814
Adjuster lever (L) Wagner F44480
Adjuster lever (L) Wagner F44481
Adjuster cable Wagner F41983
Adjuster cable guide Wagner F41987
Rear brakes 10 x 1 3/4 (8 cyl.)
Shoes Ray 31
Drum Ray 2507
Studs Ray 1113B
Nuts Ray 1200N
Spring kit Ray H7064
Self-adjusting kit (L) Ray H2514
Self-adjusting kit (R) Ray H2515
Individual hardware (Raybestos)
Return Screw Pin/ Top Hold Pin Hold
Spring Spring Anchor Cup Spring Lock Kit
6 cyl. (all) H181 H413 H1134 N/A H1156 H1177 H4035
8 cyl. (Front) H102 H405 H1108 H1132 H1157 H1177 H4030
(Rear) " " H1106 " " " "
Left Right Cable L Adj. R Adj.
Lever Lever Guide Cable Ass'bly Ass'bly
6 cyl. (all) H2035 H2036 H2090 H2100 H1522 H1523
8 cyl. (all) H2035 H2036 H2090 H2101 H1522 H1523
Front bearings,
Inner CRA BR6 BCA/Fed A-6
Outer CRA BR2 BCA/Fed A-2
Seal CRA 16659 Rockhill G16659 (7022S)
Spindle nut kit ? 304990.1
Dust cap Motormite 13975
Wheel stud 1/2-20 x 13/8" NAPA 641-1114
Nut 1/2-20 x 13/16" NAPA 641-2024
[Top]
STEERING / SUSPENSION
Shocks, front NAPA LE10006 Monroe LE10006 KYB KG4503 Delco 520-318
Gabriel 82069
(Spirit rear) NAPA NS94049 Gabriel 73509 Monroe 20830, 31125 Delco 500-343, 520-160,
KYB 344052 Gabriel 81411 Sears 98127 560-79, 500-151, 500-343
Shocks, rear NAPA NS94013 Gabriel 48474, Monroe 5818, 5818NA, Delco 500-306, 520-369,
KYB KG5521, 82155, 42340 20818, 32126, 560-94, 500-306, 500-4
343135 LE40510
Trunnion kit TRW 10234 ? SS708 NAPA/NCP 2801499
(1 side, no thrust bearing)
Thrust bearing kit AMC 320-4934 ? SS934
Thrust bearing alone AMC 316-3284 Hoover 3061-R Nice 7480, 5210W
Trunnion bushings,
Upper Moog K3036 (Clevebloc FG 80222 B-52)
Lower Moog K3059
Tie rod,
inner NAPA 269-2296 Moog DS757
outer NAPA 269-2185 Moog ES368RL Sturdy APD ES368L
sleeve NAPA 269-1126 Moog ES645S Sturdy APD ES2032S
Ball joint,
Series 01, 30, 70 TRW 10216 Moog K3058 Sturdy APD BJ10207
AMC 260-1080 Dana 2601080 S-P 80110216
Series 10, 50, 80 AMC 260-1074 Moog K3011 TRW 10207
Pitman arm,
1" shaft TRW 18773 Moog K3106
1 1/8" shaft TRW 18655N Moog K3055PS
Idler arm Moog K3074 TRW 18714
Idler arm bushing NAPA 268-3502 Moog K3026 TRW 18615 Sturdy APD H18714
Strut rod bushing NAPA 274-9044 Moog K3108 TRW HB1044
(replaces Moog 3075)
Control arm bushing,
Upper
Lower NAPA/NCP 267-3245 Moog K3059 TRW 12245 McQuay-Norris FB263
Cam bolt NAPA/NCP 264-3619
Turn signal cam Motormite 49302
Turn signal
cancel spring NAPA 735-2781 Motormite 49312
[Top]
CLUTCH (9 1/8" disk, 1" 10-spline hub)
Throwout bearing BCA R1605C B-W N1491 CR N1701
(bearing only) BCA 1505
Friction disk Ray R3353 B-W 373353 (rebuilt) Arrow/A1 CD3353
B-W CD3353 (new)
Pressure plate Ray CA1669 B-W 351599 (rebuilt) Arrow/A1 CA1599
B-W 361669 (new)
Pilot bushing Motormite 14668
Throwout lever
bellhousing boot Kennedy CL646
TRANSMISSION (T-96 3-speed manual)
Transmission mount
(rear motor mount) Mopar J3169736 Kennedy TM855
===============================================================
T-96H rebuild parts, per 1992 order from
Rockland Standard Gear (800-227-1523)
Rockland
Part No. Description
N6307NJX Bearing, ball, front (N307LOE)
6206NRJ Bearing, ball, rear (6206NR, 206L)
15041 Seal, rear (UHO190EO, 8850A)
SP96F-50 Small parts kit1
T96-55C Gasket set
1Does not include O rings and taper pins for shift levers
or enough roller bearings for main gear cluster
---------------------------------------------------------------
T-96H rebuild parts, per 2001 order from
Northwest Transmission Parts (937-442-2811)
Northwest
Part No. Description
BCA 307LOE Bearing, ball, front
ND 43206 Bearing, ball, rear
71-11123 Seal, rear
SP96F-50 Small parts kit1
G-611 Gasket set
31638 Bushing, tail housing, 1.5" ID,
1.625" OD, 1" long2
3113033 Oil slinger, 2.75" OD, 1.375" ID
1394874 Roller bearing (21), 0.125" thick, 0.719" long3
1Does not include O rings and taper pins for shift levers
or enough roller bearings for main gear cluster
2Original was 1.5" long
3Maximum usable length; original was 0.625" long
===============================================================
U-joints, front & rear PDQ 1004, 1-0153
[Top]
ELECTRICAL
Brake light switch General 31181 SMP SLS66 B-W S237
NIEH OR148 Wells DR496
Backup light switch Mopar J3189128
Front park/signal light
socket (2-filament) NAPA LS6388
Backup light socket
(1-filament) NAPA LS6389
Turn signal cam Motormite 49302
MISCELLANEOUS
Windshield reveal molding
clips (AMC J-4001377) Restoration Specialties & Supply Inc. Part 2628
Transmission filter Pur P228 AC PF190 Fram FT1030
(199 3-speed auto) Motorcraft FT 30 Wix 51706
Key blanks Star OBR3 (round), HBR3 (hex) Briggs & Stratton 320944
Ilco/EZ RA1 (round), RA2 (hex) Ilco 1098NR, H1098NR
ESP RA1, RA2 (short) Taylor 98XL, H98XL
[Top] [Rambler Dan’s AMC Home] [Paul Dwyer’s home page]